Largest Helicopter in the World

Discussion in 'Indian Air Force' started by Rahul92, Apr 27, 2011.

  1. Rahul92

    Rahul92 Senior Member Senior Member

    Joined:
    Sep 4, 2010
    Messages:
    1,622
    Likes Received:
    748
    Largest Helicopters in the World

    The article you mention discusses several of the largest planes in the world. It also describes how aircraft are typically ranked by weight rather than by physical dimensions like length or wingspan. The same holds true for helicopters. Although the diameter of the rotor is often a useful measure of a helicopter's size, these vehicles are most often ranked by maximum takeoff weight. As was also true of the largest planes, the ranks of largest helicopters are largely dominated by craft originally built in the Soviet Union. Perhaps that should be no surprise given the vast size of that nation and the need to transport large cargoes to distant and remote locations.

    1. Mil V-12 : 231,485 lb (105,000 kg)
    [​IMG]
    Mil V-12, largest helicopter in the world
    The largest helicopter ever built was a massive aircraft developed in the Soviet Union during the 1960s called the Mil V-12. The V-12 was a rather unusual test vehicle that featured two rotors mounted side by side at the ends of a large wing. Each rotor had a diameter of nearly 115 ft (35 m). The helicopter was so enormous that the distance from the edge of one rotor disk to the other was almost 220 ft (67 m), even wider across than the wingspan of a Boeing 747!
    Even more remarkable was the lifting capacity of this powerful craft. The V-12 had a maximum takeoff weight of 231,485 lb (105,000 kg), nearly twice that of the second largest helicopter, and set a record in 1969 for carrying a payload of 88,635 lb (40,205 kg). So massive was the V-12 that this payload weight alone is greater than the maximum takeoff weight of the third biggest helicopter in the world! These impressive figures have earned the V-12 the record as the world's largest helicopter according to the FAI and the Guinness Book of World Records.

    Only two V-12 prototypes were built, yet despite its amazing size and lifting power, the design was considered a failure by its manufacturer and Soviet authorities. The V-12 was simply too big and difficult to maneuver to be a practical machine. A production model would have been called the Mi-12, but these plans were cancelled following evaluation of the two test vehicles. One of the V-12 prototypes was retired to the Russian Air Force Museum in Monino while the second is kept at the Mil factory near Moscow.



    2. Mil Mi-26 : 123,455 lb (56,000 kg)
    [​IMG]
    Mil Mi-26 recovering an American CH-47 Chinook helicopter
    Because the V-12 had been judged unsatisfactory, Mil was again tasked with designing a large heavy-lift helicopter for military and civil use. The resulting Mi-26 was far more compact than the V-12 due to advancements in propulsion technology, making the Mi-26 much less cumbersome to operate. With a maximum takeoff weight of 123,455 lb (56,000 kg), the Mi-26 is the world's second largest helicopter overall and the largest ever to go into production as well as the largest flying today.
    though substantially smaller than the V-12, the Mi-26 carries a considerable payload up to 44,000 lb (20,000 kg). The Mi-26 has proven much more powerful and efficient than its predecessors thanks in part to its eight-bladed main rotor. This rotor is only 106 ft (32 m) in diameter compared to the 115 ft (35 m) diameter rotors used aboard other giant Russian helicopters but can lift greater loads due to improvements in engines and blade design. Over 200 examples of the Mi-26 were built and the type remains in use throughout Russia. Several have also been sold to civilian firms and foreign nations.


    3. Mil Mi-6 : 97,000 lb (44,000 kg)
    [​IMG]
    The third and fourth largest helicopters are also Mil designs that helped prepare the way for the V-12 and Mi-26. The Soviet's first attempt to create an enormous heavy-lift helicopter came during the mid-1950s with the introduction of the Mi-6. Designed for many of the same duties as the improved Mi-26 some 25 years later, the Mi-6 had a maximum takeoff weight of 97,000 lb (44,000 kg) and could carry up to 24,250 lb (11,000 kg) of payload. The rotor used on the Mi-6 was the same 115 ft (35 m) diameter rotor system that would also be used on the V-12.
    The Mi-6 was the world's largest helicopter when it was first built and retained the title for many years until the appearance of the V-12. The Mi-6 proved quite successful for its time as illustrated by the large number built. Some 860 were manufactured between 1960 and 1981 primarily for the Soviet Air Force and the civil airline Aeroflot. Additional models were also exported to several Soviet allies. These helicopters remained in use for over 40 years but are finally being phased out. In spite of its age, the Mi-6 still remains a remarkable vehicle and one of the largest helicopters ever conceived


    4. Mil Mi-10 : 83,775 lb (38,000 kg)
    [​IMG]
    Mil Mi-10 showing its long landing gear legs
    Yet another member of this related family of giant helicopters was the Mi-10. The Mi-10 was a specialized variant of the Mi-6 called a flying crane. The Mi-10 borrowed the engine and dynamic systems of the Mi-6 but these were mounted within a new fuselage. Unlike the wide Mi-6 fuselage that featured hinging doors for loading cargo internally, the Mi-10 fuselage was instead configured for passengers. This fuselage
    stood atop four widely spaced, extended-length landing gear legs designed to straddle large, bulky payloads carried below the helicopter.
    Both the Mi-6 and Mi-10 shared the same 115 ft (35 m) diameter rotor that was also used aboard the V-12. Compared to the Mi-6, however, the Mi-10 had a reduced maximum takeoff weight of 83,775 lb (38,000 kg) ranking it as the fourth largest helicopter ever built. Only about 55 Mi-10 helicopters were made and the type saw relatively little use. Both its flying crane mission and the transport duties of the Mi-6 have since been taken over by the far superior Mi-26.


    5. Sikorsky CH-53E : 73,500 lb (33,340 kg)

    Coming in as the fifth largest helicopter in the world is the biggest ever built in the United States, the Sikorsky CH-53E Super Stallion. The CH-53E is an enlarged model of the earlier CH-53 Sea Stallion. Both vehicles were originally developed as heavy-lift helicopters for the US Marine Corps, and they have also been used by the Navy, Air Force, and allied countries. The largest variant of the CH-53 family developed so far is the CH-53E with a maximum takeoff weight of 73,500 lb (33,340 kg). Though comparable in physical dimensions to other H-53 models with a main rotor 79 ft (24.1 m) in diameter, the CH-53E and related MH-53E are equipped with an extra engine of increased power to lift a significantly greater payload.

    [​IMG]
    CH-53E Super Stallion lifting an F-15 Eagle fighter

    Approximately 115 examples of the CH-53E and MH-53E Sea Dragon variant were built, and these remain the largest helicopters in military service in the West. However, a new version of the venerable H-53 design is currently under development. Known as the CH-53K, this improved model will carry more powerful engines and new rotor blades to increase maximum takeoff weight to 84,700 lb (38,420 kg). Once this enhanced variant becomes available, the CH-53K should narrowly beat the Mi-10 to become the world's fourth largest helicopter.

    6. Boeing Vertol MH-47E/G : 54,000 lb (24,495 kg)

    The next largest helicopter is the Boeing Vertol CH-47 Chinook also developed in the United States. The H-47 family began development during the late 1950s as an enlarged variant of the CH-46 Sea Knight and has proven to be one of the most successful series of military heavy-lift helicopters. The design features a long, spacious fuselage powered by two engines driving a pair of tandem rotors 60 ft (18.3 m) in diameter. The type is widely used for transporting troops, carrying heavy military equipment like artillery slung underneath the fuselage, and resupply missions. Though the primary users are the US Army and British Royal Air Force, the CH-47 has been sold to over 20 nations as well as civilian operators

    [​IMG]
    The single largest versions of the H-47 developed to date are the MH-47E and MH-47G special operations models. While most CH-47 variants have a maximum takeoff weight around 50,000 lb (22,680 kg), the MH-47E/G have been upgraded to 54,000 lb (24,495 kg). Over 1,000 Chinooks have been built to date and production of newer CH-47F, MH-47G, and HH-47 models continues today.


    7. Hughes XH-17 : 50,000 lb (22,680 kg)

    Coming in as the seventh largest helicopter is a unique prototype called the XH-17 Sky Crane. The Sky Crane was the first helicopter built by Hughes Aircraft, the same company that had also built the behemoth Spruce Goose flying boat during the 1940s. Shortly thereafter, Howard Hughes became interested in helicopter technology and purchased a design for a giant transport helicopter from the Kellett company. Similar to the Russian Mi-10, the Sky Crane was equipped with four long landing gear legs to straddle large oversized payloads carried underneath the fuselage. The H-17 was lifted by a massive two-blade rotor system 134 ft (40.8 m) across, still the record for the largest rotor ever flown

    [​IMG]
    Construction of a single XH-17 prototype began during the late 1940s for use as a research vehicle. The craft was completed by 1952 when it began a three-year testing period. The maximum takeoff weight ever attempted aboard the Sky Crane was over 50,000 lb (22,680 kg) during a flight in 1953. However, the research program concluded the design was too large and cumbersome to be useful and no further models were built. Hughes also designed an enlarged variant called the H-28 that would have doubled the maximum weight to nearly 104,000 lb (47,000 kg), but further development was cancelled following experience with the XH-17.


    8. Sikorsky CH-54 : 47,000 lb (21,320 kg)

    Rounding out this list of large helicopters is another American design called the Sikorsky CH-54 Tarhe. Like the Mi-10 and XH-17, the CH-54 was a flying crane helicopter designed to haul large payloads slung below the fuselage. The unusual looking helicopter featured an upper spine containing the engines driving the 72 ft (21.9 m) diameter main rotor. At the front of this spine was the cockpit with windows facing both forward and aft allowing crew to monitor the payload. This minimal fuselage structure made the CH-54 a very efficient design compatible with various cargo modules that could be hoisted into position behind the cockpit for low drag.

    [​IMG]
    CH-54 Tarhe recovering a damaged F-4 Phantom II


    With a maximum takeoff weight of 47,000 lb (21,320 kg), the CH-54 was designed primarily for transporting military cargoes like artillery, ground vehicles, and other bulky supplies. Its lifting capabilities were frequently used during the Vietnam War to move aircraft or recover downed planes and helicopters. A civil model called the S-64 Skycrane was also developed and became popular with the logging industry and for firefighting. About 105 of these helicopters were built, and though retired from military service, several remain in civilian use.

    Summary

    Further illustrating just how large the helicopters described above are is the fact that no other helicopter exceeds a maximum weight of 35,000 lb (15,875 kg). The majority of helicopters are indeed quite small next to these giants since there is relatively little demand for such enormous vehicles compared to more moderately sized designs. Yet even among these giants, the size differential between them is hard to comprehend. The following diagram compares the Russian V-12 and Mi-26 to the American CH-53E. Despite its enormous size relative to any other Western helicopter, the Super Stallion almost seems a toy next to the two largest helicopters ever built.


    [​IMG]






    http://www.aerospaceweb.org/question/helicopters/q0284.shtml
     
    Last edited: Apr 27, 2011
    kuwaronline, nitesh and Godless-Kafir like this.
  2.  
  3. Rahul92

    Rahul92 Senior Member Senior Member

    Joined:
    Sep 4, 2010
    Messages:
    1,622
    Likes Received:
    748
    It clearly states that Russia has dominated in Helicopter aviation industry
     
  4. Rahul92

    Rahul92 Senior Member Senior Member

    Joined:
    Sep 4, 2010
    Messages:
    1,622
    Likes Received:
    748
    But actually Russian copters give less mileage compared to USA copters
     
  5. Armand2REP

    Armand2REP CHINI EXPERT Veteran Member

    Joined:
    Dec 17, 2009
    Messages:
    10,397
    Likes Received:
    2,314
  6. pmaitra

    pmaitra Moderator Moderator

    Joined:
    Mar 10, 2009
    Messages:
    31,640
    Likes Received:
    17,115
    Location:
    EST, USA
    Actually, even Sikorsky was a helicopter engineer who studied and practiced helicopter designing in France and Russia before moving to the US.
     
  7. Blackwater

    Blackwater Veteran Member Veteran Member

    Joined:
    Jan 9, 2012
    Messages:
    20,982
    Likes Received:
    11,810
    Location:
    Akhand Bharat
    In nutshell Sikorsky was Russian citizen before he moved to free land usa
     
    pmaitra likes this.
  8. asianobserve

    asianobserve Elite Member Elite Member

    Joined:
    May 5, 2011
    Messages:
    7,308
    Likes Received:
    2,976
    Giant helicopters do not make very good business propositions. They're a niche market with a very limited demand as most helicopter demand is on medium sized choppers. It is no accident therefore that these gigantic choppers became so gigantic only in the USSR. The helicopter manufacturers there did not have to contend with free market forces. The state ensured that these helicopters will be acquired no matter how poor the business feasibility was. Moreover, these behemoths were sorts of badges of the Soviets' technological might, well until market forces humbled them.
     
  9. JAISWAL

    JAISWAL Senior Member Senior Member

    Joined:
    Mar 13, 2010
    Messages:
    1,512
    Likes Received:
    1,016
    Location:
    ghaziabad
    World’s First Mil V-12 Hotel Cum helicopter

    [​IMG]

    Imagine a five star hotel flying in air now times time to move on and experience the world’s first flying hotel. Unbelievable but it’s true recently a soviet Mil V-12 helicopter has been modified and now it turned in to the world’s biggest helicopter as well as first flying hotel.

    Amazing look at the great design of this biggest hotel cum helicopter is about 135 feet long and 45 feet high. This helicopter is able to lift the maximum load of 105 thousand kilos off the ground and travel at very high speed of about 158 miles/hour.

    Mil V-12 helicopter will take first flight on 26th of June. Some rich people may buy this luxurious helicopter for personal use but sources are unable give you information about the price of the cool biggest helicopter. Pictures are showing the internal luxury arrangement to provide you an exciting and comfort experience so enjoy flying in the sky.
    .
    Inside the rooms
    .
    [​IMG]
    [​IMG]
    [​IMG]
    [​IMG]
     
    buddhadeb and pmaitra like this.
  10. pmaitra

    pmaitra Moderator Moderator

    Joined:
    Mar 10, 2009
    Messages:
    31,640
    Likes Received:
    17,115
    Location:
    EST, USA
    ^^ Great post bud!

    Thanks and bunch!
     
  11. JAISWAL

    JAISWAL Senior Member Senior Member

    Joined:
    Mar 13, 2010
    Messages:
    1,512
    Likes Received:
    1,016
    Location:
    ghaziabad
    some more pictures.
    .
    [​IMG]
    .
    [​IMG]
    .
    .
    [​IMG]
    Columbia Helicopters in Alaska attempting to tow a barge... with a 600 foot cable and up to 25 degrees nose low attitude
     
  12. JAISWAL

    JAISWAL Senior Member Senior Member

    Joined:
    Mar 13, 2010
    Messages:
    1,512
    Likes Received:
    1,016
    Location:
    ghaziabad
    Few more details and pics.
    .
    [​IMG]
    .
    .
    [​IMG]
    .
    [​IMG]
    CH-54 Tarhe recovering a damaged F-4 Phantom II:
    [​IMG]
    The Fairey Rotodyne, 1959, advertised as the "first vertical take-off airliner in the world" (project scrapped in 1962) and the first helicopter airline in the world: New York Airways, 1953
     
  13. JAISWAL

    JAISWAL Senior Member Senior Member

    Joined:
    Mar 13, 2010
    Messages:
    1,512
    Likes Received:
    1,016
    Location:
    ghaziabad
    [​IMG]
    .
    [​IMG]
    Sure it has rotors -- it wouldn't be a helicopter without them -- but with the V-12 they are placed on the side of its massive fuselage. Weird, right? But this is BIG weirdness as the V-12 is commonly considered to be the largest helicopter in the world. How big? Think of it this way: see that 747 over there -- that monstrous fixed wing machine? Well, the V-12 is as wide as one of those 747s. But unlike a 747, the V-12 can take off straight up, and haul close to 55,000 pounds at the same time -- or 88,000 if it takes off a bit less like a helicopter and more like a plane.
    Courtesy:-
    http://darkroastedblend.com/2009/03/monstrous-aviation-part-2-huge.html
    .
    .
    [​IMG]
    .
    .
    [​IMG]
     
    Last edited: Jun 3, 2011
  14. JAISWAL

    JAISWAL Senior Member Senior Member

    Joined:
    Mar 13, 2010
    Messages:
    1,512
    Likes Received:
    1,016
    Location:
    ghaziabad
    [​IMG]
    When compared with a typical Chinook, Mi-26 does indeed look big:
    [​IMG]
    November 2003, a U.S.-led coalition launched Operation Mountain Resolve in the Nuristan and Kunar provinces of Afghanistan. The above-displayed photograph of the precarious-looking rooftop landing by a CH-47 Chinook helicopter was taken during that operation by U.S. Army Sgt. Greg Heath. The Chinook helicopter is touching down to receive Afghan Persons Under Control (APUC) captured by members of the U.S. 10th Mountain Division"
     
    buddhadeb likes this.
  15. JAISWAL

    JAISWAL Senior Member Senior Member

    Joined:
    Mar 13, 2010
    Messages:
    1,512
    Likes Received:
    1,016
    Location:
    ghaziabad
    compair Mi-v12 with Mi-26.
    .
    .
    [​IMG]
    .
    .
    See the incredibal way chinook could support spl.opration , see its landing style.
    .
    .
    [​IMG]
    .
    .
    "November 2003, a U.S.-led coalition launched
    Operation Mountain Resolve in the Nuristan and
    Kunar provinces of Afghanistan. The above-
    displayed photograph of the precarious-looking
    rooftop landing by a CH-47 Chinook helicopter
    was taken during that operation by U.S. Army
    Sgt. Greg Heath. The Chinook helicopter is
    touching down to receive Afghan Persons Under
    Control (APUC) captured by members of the U.S.
    10th Mountain Division"
    .
    .
    [​IMG]
     

Share This Page